american ac & appliance
Techtips

Dishwasher Tips

Appliance Parts
Online
maytag, whirlpool, KitchenAid,Ge, Hotpoint, Sears, Kenmore, Roper

D&M Built Sears / Kenmore / Roper / frigidaire / magic chef / Dishwasher Pump Breakdown

Symptom Solution Images

dmdw1.jpg (71437 bytes)

dmdw2.jpg (101197 bytes)

dmdw3.jpg (80454 bytes)

dmdw4.jpg (98466 bytes)

dmdw5.jpg (41025 bytes)

dmdw6.jpg (49462 bytes)

dmdw7.jpg (43044 bytes)

dmdw8.jpg (47858 bytes)

dmdw9.jpg (51189 bytes)

dmdw10.jpg (51175 bytes)

dmdw11.jpg (62900 bytes)

ventbaffle.jpg (52685 bytes)

Popular Door Gasket & Vent Baffle
gasketandventbaffle.jpg (80324 bytes)
Dishwasher will not complete a cycle.
  • Check the timer for proper operation
  • Check timer switch leads to timer motor
  • Compare timer with sequence chart on wiring diagram
  • Make sure all leads to the timer are secure and tight
  • Some models have a thermostat. Check to make sure it is in contact with the tub.
Dishwasher will not drain.
  • Check for hose kinks or food plugging drain hose.
  • Check pump impeller for damage
  • Check pump motor for reversing during the pump out
  • Check timer
  • If you have recently installed a new garbage disposal, check knock-out plug at connection.
Dishwasher will not fill with water
  • Check float switch or float.
  • Check the timer to make sure the contacts are closed for water fill valve. Look at wiring diagram for contact numbers
  • Check the water supply tube for blockage.
  • Check water supply valve. There should be 110 volts to the coil.
  • Water valves have screens in them that sometimes will plug with sand. Either clean or replace the screen filter.
Dishwasher will not get the dishes clean.
  • Check pump recirculation.
  • Check the screen in the water fill valve.
  • Check the spray arm for splits or leaks.
  • Check the water pressure or manual valve.
  • Check the water temperature. Should be 135 to 160 F.
  • Check to make sure dishwasher is draining after each cycle. There should only be a little water in the bottom of the tub.
  • Check water level when the fill cycle has completed. Should be barely touching, or just under the float.
  • Make sure the dishes are loaded properly, or dishwasher is not overloaded.
  • Try a different detergent.
Dishwasher will not run at all.
  • Check connections from power cord to terminal block.
  • Check door switch for action and continuity
  • Check power at outlet. Should read 110 volts.
  • Check the timer for power
Water leaks from the bottom of the dishwasher.
  • Check air gap for mineral deposits. This will cause the water to spray out of the air inlet.
  • Check for cracks or rust  in the tub.
  • Check the float switch
  • Check the heater element where it enters the tub. There are gaskets that sometimes leaks.
  • Check the hose clamps.
  • Check the hoses for leaks.
  • Check the door gasket. If you replace the door gasket, replace the baffle seal that runs along the bottom also.
  • Check the seals in the pump for leakage
Water leaks from the door.
  • Check corner seals and bottom dam seal
  • Check door seal
  • Check for loose or bent door latch
  • Check for over filling. This could be from flaot switch. The water should never or barely reach float. The float switch is for overflow.
  • Check the spray arm for a split. If water sprays directly at the bottom of door, it will create a leak.
 

 

 

Didn't Find Your Answer Here? Try Submitting Your Request
Or If You Prefer  The Service Dept.
| Parts | Sales | Techline | E-Mail | History |
| Address | Home | Helpful Hints |

Appliance parts, electrical supplies, bulbs, flourescent, general electric, whirlpool, amana, maytag, frigidaire, appliances, tools, test equipment, kenmore, Magic Chef, Admiral, Kitchen Aide, Emerson, Vicking, Crosley, wizard, citation, estate, litton, jcpenney, philco, tappan, white westinghouse, gibson, kelvinator, roper, rca, hotpoint, jennaire, norge, hardwick, broich, commercial cooking, commercial laundry, huebsch, chambers, menumaster, coolerator, central vaccuum, fans, pedastal, filters, friedrich, warwick, dacor, speedqueen, fasco, patton, klein, microwave, fedders, sears, penncrest, modern maid, sunray, brown, broan, artic air, imperial, scotsman, crest, dometic, edina technical, fedpak, general freezer, harvard, holmes, lechmere, logik, peerless premier, venex, western auto, montogomery ward, southern foods, eagle, airtemp, hamilton, caloric, hunter, marta, hampton bay, comfort bay, rangaire, nautilus, athens, ise, in-sink-erator, robertshaw, honeywell, bristol compressor, gemlineAppliance parts, electrical supplies, bulbs, flourescent, general electric, whirlpool, amana, maytag, frigidaire, appliances, tools, test equipment, kenmore, Magic Chef, Admiral, Kitchen Aide, Emerson, Vicking, Crosley, wizard, citation, estate, litton, jcpenney, philco, tappan, white westinghouse, gibson, kelvinator, roper, rca, hotpoint, jennaire, norge, hardwick, broich, commercial cooking, commercial laundry, huebsch, chambers, menumaster, coolerator, central vaccuum, fans, pedastal, filters, friedrich, warwick, dacor, speedqueen, fasco, patton, klein, microwave, fedders, sears, penncrest, modern maid, sunray, brown, broan, artic air, imperial, scotsman, crest, dometic, edina technical, fedpak, general freezer, harvard, holmes, lechmere, logik, peerless premier, venex, western auto, montogomery ward, southern foods, eagle, airtemp, hamilton, caloric, hunter, marta, hampton bay, comfort bay, rangaire, nautilus, athens, ise, in-sink-erator, robertshaw, honeywell, bristol compressor, gemlineAppliance parts, electrical in-sink-erator, robertshaw, honeywell, bristol compressor, gemline